Product ID:N0 1305 SAFETY SOLVENT
MSDS Date:01/22/1990
FSC:6840
NIIN:00N020167
MSDS Number: BLHTK

HILL MANUFACTURING CO INC

1500 JONESBORO DR
ATLANTA, GA 30315
US

Emergency Phone: 404-522-8364

Info Phone: 404-522-8364

Preparer: RICK GLISSON

Cage: 66086

HILL MANUFACTURING CO INC

ATLANTA, GA 30315 US

Telephone: 404-522-8364

Cage: 66086

PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SARA III)

CAS: 127-18-4

RTECS: KX3850000

Fraction By Weight: 25-35%

OSHA PEL 100 PPM

ACGIH TLV: 25PPM/100,A3 STEL;94

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

NAPHTHA, HEAVY ALKYLATE; (ALIPHATIC HYDROCARBONS) (LIMITS

CAS: 64741-65-7

Fraction By Weight: 65-75%

OSHA PEL 300 PPM;400 PPM STEL

ACGIH TLV: 300 PPM

GIVE ARTIFICIAL RESP. KEEP WARM, QUIET & GET

RTECS: 9999999ZZ

DIKE AREA OF SPILL TO PREVENT SPREADING, PUMP

RTECS: 9999999ZZ

SAND, CLAY, EARTH, FLOOR ABSORB/OTHER ABSORB MATL &

RTECS: 9999999ZZ

CONTAM ABSORB MAY BE DEPOSITED IN LANDFILL

RTECS: 9999999ZZ

FORMATION OF HCL AND/OR PHOSGENE .

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRIT, REDNESS,
TEARING/BLURRED VISION. SKIN:PRLNGD/RPTD CNTCT CAN CAUSE MOD IRRIT,
DERMATITIS. INHAL:EXCESSIVE INHAL OF VAP CAN CAUSE NASAL/RESP
IRRIT, DIZZ, WEAKNESS/FATG, NAU S, HDCHE, POSSIBLE UNCON/EVEN ASPY.
INGEST:CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZ:OVEREXP TO MATL HAS APPARENTLY BEEN
FOUND TO CAUSE THESE EFFECTS IN HUMANS:CARDIAC/LIVER ABNORM,
KIDNEY/ LUNG DMG. CHLOROCARBON MATLS HAVE PROD SINSIT OF THE
MYOCARDIUM TO EPINEPHRINE IN LA B ANIMALS & COULD HAVE A SIMULAR
EFFECTIN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN:THOROUGHLY WASH EXPOS AREA W/SOAP & H2O. REMOVE CONTAM
CLTHG. LAUNDER CONTAM CLTHG BEFORE RE-USE. EYES:FLUSH WITH LARGE
AMOUNT OF H2O FOR AT LEAST 15 MIN, LIFTING UPPER/LOWER LIDS OCCAS.
GET MD A TTN. INGEST:DO NOT INDUCE VOMIT. CALL MD OR TRANSPORT TO
EMER FACILITY. INHAL:IF AFFECTED, REMOVE INDIVIDUAL TO FRESH AIR.
IF BRTHG IS DIFFICULT, ADMINISTER O2. IF BRTHG HAS STOPPED (INGRED
3)

Flash Point Method:TCC
Flash Point:125F,52C
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:H2O MAY BE USED TO KEEP FIRE-EXPOSED CONTRS
COOL UNTIL FIRE IS OUT. WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND
SCBA & FULL PROT EQUIP. TREAT AS PETROLEUM FIRE.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PROD MAY INCLUDE HCL &
PHOSGENE . NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUM (EVEN
EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) (SUPP DATA)

Spill Release Procedures:AVOID FIRE. SMALL SPILLS:ABSORB LIQ ON PAPER,
VERMICULITE, FLOOR ABSORB/OTHER ABSORB MATL. LARGE SPILLS:PERSONS
NOT WEARING PROT EQUIP SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL
CLEAN-UP HAS BEEN COM PLETED. STOP SPILL AT SOURCE, (ING 4-5)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTRS OF MATL MAY BE HAZ WHEN
EMPTIED, SINCE EMPTIED CONTRS RETAIN PROD RESIDUE (VAP/LIQ/SOLIDS)
ALL HAZ PREC GIVEN ON DATA SHEET MUST BE OBSERVED.
Other Precautions:NEVER STORE IN UNLABELED/IMPROPERLY LBL CONTR. KEEP
OUT OF REACH OF CHILDREN. FOR COMMERCIAL/INDUST USE ONLY. NO
SMOKING IN AREA OF USE. DO NOT USE IN GEN VICIN OF ARC WELDING/OPEN
FLAMES/HOT SURF. HE AT AND/ OR UV RADIA MAY CAUSE (ING 7)

Respiratory Protection:IF TLV OF PROD OR ANY COMPONENT IS EXCEEDED, A
NIOSH/MSHA APPROVED AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF
PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA RESP
UNDER SPECIFIED CONDIT IONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOC EXHAUST)
VENT TO MAINTAIN EXPOS BELOW TLV(S).
Protective Gloves:NEOPRENE GLOVES (PROLONGED USE)
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS. EMERGENCY EYE WASH AND
DELUGE SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLOS HAZ:CAN IGNITE EXPLOSIVELY. TOXIC GASES MAY BE RELEASED WHEN
EXPOS TO FIRE. MATL TO AVOID:WHICH CAN RESULT IN THERMAL DECOMP
RELEASING HYDROGEN CHLORIDE/SMALL AMOUNTS OF PHOSGENE/ CHLORINE.
EFF TS OF OVEREXP:EXCEPT FOR LIFE SUSTAINING USES IN HUMANS ACUTELY
OR CHRONICALLY EXPOSED TO CHLOROCARBONS .

HCC:F4
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:100 @ 68F
Vapor Density:4.5
Spec Gravity:1.1
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:NIL
Appearance and Odor:COLORLESS LIQUID WITH TYPICAL CHLORINATED SOLVENT
ODOR.
Percent Volatiles by Volume:50-70

Stability Indicator/Materials to Avoid:YES
WATER, REACTIVE METALS SUCH AS ALUMINUM AND MAGNESIUM, OPEN FLAME,
WELDING ARCS, RESISTANCE HEATERS, ETC., (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE, PHOSGENE,
VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:SMALL SPILLS:ALLOW VOLATILE PORTION TO EVAP IN
HOOD. ALLOW SUFFICIENT ITEM FOR VAP TO COMPLETELY CLEAR HOOD DUCT
WORK. DISPOSE OF REMAINING MATL IN ACCORDANCE W/FED/STATE/LOC REGS.
LARGE SPILLS: DESTR OY BY LIQ INCIN W/OFF-GAS SCRUBBER. (INGRED 6)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.